Volkswagen›Passat›1995›Overview/volkswagen/passat/1995/base/

1995 Volkswagen Passat

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 1995 Passat.

Body PASSENGER CAR

The 1995 Volkswagen Passat, a passenger car specified for 4.2 quarts of 5W-30, 5W-40, or 10W-30 oil, accumulated 123 owner complaints with visibility topping the categories and one recall issued. In the broader 1990–2022 model history, that total falls far short of the 2013 high of 747 complaints but exceeds the 2022 low of 11, situating the 1995 model year in the lower-midrange of the lineup's reported issue volume. This placement indicates the 1995 Passat avoided the pronounced complaint surges of later generations while still carrying the baseline scrutiny of a mid-1990s sedan.

Model year2022 2021 2020 2019 2018 2017 2016 2015 1995

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity4.2 qtOEM · verified

Engine oil type5W-30 / 5W-40 / 10W-30OEM · verified

Lug nut torque81 ft-lbsOEM · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 42 · 460 CCA battery, OE oil filter 056115561G. Note the factory engine air filter and cabin air filter are now discontinued — plan on a superseded or quality aftermarket equivalent, which the part pages below list where known. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 42 · 460 CCAOEM · verified

Tail / brake / turnLIGHTOEM · verified

Tire size195-60HR14OEM · verified

Wheel / rim6-J inOEM · verified

OE service part numbers OEM · verified

Engine oil filter	056115561G alt 021115562
Engine air filter	191129620 discontinued
Fuel filter	1H0201511A
Spark plug	101000044AA alt 101000035AH
Front wiper blades	357955427 alt 3A1955427
Serpentine belt	037903137G alt 037260849C
Thermostat	044121113 alt 075121113D
Cabin air filter	3A0819644 discontinued

Full specifications

Engine, drivetrain, dimensions and economy.

Dimensions & weight NHTSA vPIC

Overall length	181.5 in
Overall width	67.7 in
Overall height	56.3 in
Wheelbase	103.5 in
Curb weight	2976 lb
Track (front / rear)	57.5 / 55.9 in
Weight distribution (front / rear)	62/38

Performance & power Independent road tests

0–60 mph, quarter-mile, horsepower and torque from independent road tests.

Independent road tests for the Passat of this era, listed by trim and engine — this page spans more than one engine, so no single horsepower figure is shown.

7.7–11.0 sec0–60 mph (tested)quickest 7.70 sec — 1993 GLX V6 Sedan

Year	Trim / engine	0–60	¼ mile	HP	Drivetrain
1996	TDI Sedan 1.9L Turbo Diesel I-4	11.00 sec	18.10 sec	90 hp	FWD
1993	GLX V6 Sedan 2.8L V6	7.70 sec	16.10 sec	172 hp	FWD

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 4.2 qt of 5W-30 / 5W-40 / 10W-30 engine oil, SYNTHETIC · 75W-90 · GL-4 in the differential, DOT 4 brake fluid. Torque lug nuts to 81 ft-lbs, the oil drain plug to 22.0 ft-lbs. The firing order is 1-5-3-6-2-4. Note the cylinder-head bolts finish on a torque angle (torque-to-yield) — they stretch permanently and should be replaced, not reused, during any head service.

Lubricants & capacities

Brake Fluid	DOT 4
Differential Gear Oil	SYNTHETIC · 75W-90 · GL-4
Differential Gear Oil Capacity	1.6 Pints
Engine Coolant	ETHYLENE GLYCOL
Engine Oil	5W-30 · 5W-40 · 10W-30 · 10W-40 · 5W-50 · 10W-50 · 10W-60
Engine Oil Capacity	4.2 qt
Engine Oil	5W-30 · 5W-40 · 10W-30 · 10W-40 · 5W-50 · 10W-50 · 10W-60
Engine Oil Capacity	5.8 qt

Engine torques

Intake Manifold to Engine Bolts	15 ft-lbs
Exhaust Manifold to Cylinder Head Bolts	18 ft-lbs
Intake Manifold to Engine Bolts	18 ft-lbs
Engine Oil Pan Drain Plug	22.0 ft-lbs
Engine Oil Pan Drain Plug	22.0 ft-lbs

Chassis torques

Lug Nuts

81 ft-lbs

Ignition

Cylinder Firing Order	1-3-4-2
Cylinder Firing Order	1-5-3-6-2-4
Spark Plug Manufacturer	VW
Spark Plug Gap	0.031 in
Spark Plug Torque	22.0 ft-lbs

Battery & A/C

Refrigerant	R134a
Refrigerant Capacity	2.08-2.10 lbs
Oil Group	PAG
Standard BCI Group Number	42
Standard BCI Cranking Performance	460 cca
Optional BCI Group Number	41
Optional BCI Cranking Performance	650 cca
Standard BCI Group Number	42

Service checks

Pressure Test	20-23 psi
Radiator Cap Pressure Relief	20-23 psi
Thermostat Opening Temperature	185 °F
Pressure Test	19-22 psi
Radiator Cap Pressure Relief	19-22 psi
Pressure Test	19-22 psi
Radiator Cap Pressure Relief	19-22 psi
Thermostat Opening Temperature	176 °F

Brakes

Torque Caliper to Bracket	92 ft-lbs / 26 ft-lbs / 18 ft-lbs
Torque to Knuckle	80 ft-lbs / 92 ft-lbs
Minimum Pad Thickness	Front: 0.276; Rear: 0.276 specification
Rotor Max Parallel Variation	0.0004 in
Rotor Runout Limit	0.012 in
Rotor Nominal Thickness From	0.512 in / 0.788 in / 0.985 in
Rotor Nominal Thickness To	0.512 in / 0.788 in / 0.985 in
Rotor Discard at or Under	0.433 in / 0.709 in / 0.906 in

Multi-step torque procedures OEM · verified

Cylinder Head — tightening sequence 4 stages

1	30 ft. lbs.	30 ft. lbs
2	44 ft. lbs.	44 ft. lbs
3	90 degrees.	90 degrees
4	90 degrees.	90 degrees

Cylinder Head — tightening sequence 4 stages

1	30 ft. lbs.	30 ft. lbs
2	44 ft. lbs.	44 ft. lbs
3	90 degrees.	90 degrees
4	90 degrees.	90 degrees

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter at 7,500 mi; spark plugs every 30,000 mi.

At 7,500 mi	Clutch Assembly (inspect) · Engine Oil Filter (replace)
Every 7,500 mi	Brake Shift Interlock Solenoid (inspect) · Engine Oil (drain & refill) · Hood Latch (lubricate) · Neutral Safety Switch (test) · Tire & Wheel Assembly (rotate)
Every 15,000 mi	Axle Shaft Oil Seal (inspect) · Battery (inspect electrolyte level) · Brake System (inspect) · CV Joint Boot (inspect) · Cabin Air Filter (replace) · Clutch Assembly (inspect)
Every 30,000 mi	Engine Air Filter Element (replace) · Spark Plugs (replace) · Steering Linkage (inspect)
Every 60,000 mi	Accessory Drive Belt (inspect) · Oxygen Sensor (replace)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

The 1995 Volkswagen Passat recorded 123 complaints, 1 recall, 2 investigations, and 34 Technical Service Bulletins (TSBs). This represents a sharp increase in reported issues compared to 1994, which had only 31 complaints and 11 TSBs. Within the broader generation, 1995 marks the beginning of a significant upward trend in instability, preceding a further rise to 159 complaints in 1996 and a spike to 376 by 1998. The primary complaint areas for 1995 were Visibility (19), Engine & Engine Cooling (18), and Electrical Systems (14), though the data does not specify the root causes for these failures. Safety records for this year include 4 crash complaints and 1 fire complaint. Because 1995 serves as the inflection point for increasing complaints and TSBs, it is not a recommended year to buy compared to the more stable 1990-1994 models.

Open recalls

NHTSA campaigns

Service bulletins

Manufacturer communications

ODI investigations

Office of Defects Investigation

123

Owner complaints

4 involved a crash · 1 a fire

NHTSA crash-test rating federal NCAP · out of 5 stars

Rollover★★★★★

Owner complaints by model year NHTSA · this generation & adjacent

’90 ’91 ’92 ’93 ’94’95’96 ’97 ’98 ’99 ’00 ’01 ’02 ’03 ’04 ’05 ’06 ’07 ’08 ’09 ’10 ’11 ’12 ’13 ’14 ’15 ’16 ’17 ’18 ’19 ’20 ’22

Owner complaints filed with NHTSA, by component

All 123 complaints on record, top 8 components.

Visibility19

Engine & Engine Cooling18

Electrical System14

Latches/Locks/Linkages10

Service Brakes, Hydraulic10

Power Train10

Steering4

Vehicle Speed Control4

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 1 of 1 campaigns on record for this vehicle.

95V178000Engine And Engine Cooling:Cooling System:FanReported 20/09/1995

IMPROPER MATERIAL WAS USED IN MANUFACTURING THE RADIATOR FAN MOTOR SHAFT CAUSING THE SHAFT TO WEAR AND BECOME NOISY. Remedy: DEALERS WILL REPLACE THE COMPLETE COOLING FAN ASSEMBLY ON VEHICLE HAVING THE POTENTIAL SHAFT MATERIAL PROBLEM. DEALERS WILL INSTALL A NEW FAN BLADE INCLUDING A NEW LOCK NUT ON…

Technical service bulletins NHTSA · verified

Showing 5 of 34 bulletins on record with NHTSA.

Bulletin	Date	Component	Summary
SM 33-2019	2019-03-27	Equipment	The part number listed in the document is to be returned if it meets the criteria…
SM 44-2017 EN	2017-06-28	Equipment	This special notice is to inform dealers to return all part numbers listed in the…
VHW-17-11	2017-06-22	Equipment	VAS 6154 Replacement Part Setup Guide
1-2017 Update	2017-02-01	Equipment	This communication is to update our ProFi dealers of the current status of the latest…
V691601 2010479	2016-10-31	Equipment	Update model year applicability to include 2017.

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420

Catalyst system efficiency below threshold — Bank 1

P0300

Random / multiple cylinder misfire detected

P0171

System too lean — Bank 1

P0455

Evaporative emission system leak detected — large leak

P0128

Coolant thermostat below regulating temperature

P0442

Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN

Decode a VIN to confirm the transmission and build data for a specific Passat. OEM

Build data

Plant, GVWR class, engine and body data for any 17-character VIN.

Recalls

Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Group 42 battery Vehicles taking 4.2 qt Engine oil filter 056115561G Engine air filter 191129620 Fuel filter 1H0201511A Spark plug 101000044AA

Reference guides

Cross-vehicle references for the kinds of data on this page.

Vehicle recalls & TSBs OBD-II trouble codes Torque specifications Maintenance schedules Fluid capacities & specs

Frequently asked

How much oil does the 1995 Passat take?

4.2 qt of ENERGY CONSERVING OILS: 5W-30, 5W-40, 10W-30 OR 10W-40 MEETING VW SPECIFICATION VW50200, EXCEPT ENGERGY CONSERVING OILS: 5W-50, 10W-50, OR 10W-60 MEETING VW SPECIFICATION VW50200, per the factory manual.

Does the 1995 Passat have open recalls?

NHTSA lists 1 recall campaign(s) for this model year. Check your specific vehicle by VIN.