Kia›Sportage›1995›Overview/kia/sportage/1995/base/

1995 Kia Sportage

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 1995 Sportage.

Transmission Manual 5-spd

The 1995 Kia Sportage launched with a 5-speed manual transmission and EPA ratings of 17 city, 21 highway, and 19 combined mpg, its 4.4-quart oil sump calling for 5W-20 API viscosity. Across the model's full complaint record spanning 1995 through 2026, this inaugural model year accumulated 67 owner complaints — concentrated in Engine & Engine Cooling — along with two recalls, slotting it well beneath the 394-complaint spike of 2017 yet dramatically above the four complaints logged for 2003. That positioning marks 1995 as a moderately troubled launch year that introduced engine-related issues the model would later suppress before they resurged, giving researchers a meaningful starting point for mapping the Sportage's long-term reliability arc.

Model year2026 2025 2023 2022 2021 2020 2019 2018 1995

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity4.4 qtOEM · verified

Engine oil type5W-20 APIOEM · verified

Lug nut torque65-87 ft-lbsOEM · verified

EPA fuel economy17/21/19 mpgEPA · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 58 · 470 CCA battery. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 58 · 470 CCAOEM · verified

Tail / brake / turnFUSEOEM · verified

Full specifications

Engine, drivetrain, dimensions and economy.

Engine & drivetrain NHTSA vPIC

Transmission

Manual 5-spd

Ratings & economy EPA / vPIC

EPA city / highway / combined	17 / 21 / 19 mpg
Drivetrain	Rear-Wheel Drive
Recommended fuel	Regular Gasoline

Performance & power Independent road tests

0–60 mph, quarter-mile, horsepower and torque from independent road tests.

Independent road tests for the Sportage of this era, listed by trim and engine — this page spans more than one engine, so no single horsepower figure is shown.

11.8–12.8 sec0–60 mph (tested)quickest 11.80 sec — 1996 EX

Year	Trim / engine	0–60	¼ mile	HP	Drivetrain
1996	EX 2.0L I-4	11.80 sec	18.30 sec	130 hp	4x4
1998	SUV 2.0L I-4	12.80 sec	19.10 sec	130 hp	4x4
2001	Limited 2.0L I-4	12.50 sec	19.10 sec	130 hp	4x4

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 4.4 qt of 5W-20 API engine oil, 80W-90 · GL-5 in the differential, DOT 3 · DOT 4 brake fluid. Torque lug nuts to 65-87 ft-lbs. The firing order is 1-2-3-4-5-6.

Lubricants & capacities

Brake Fluid	DOT 3 · DOT 4
Differential Gear Oil	80W-90 · GL-5
Differential Gear Oil Capacity	2.7 Pints
Engine Coolant	ETHYLENE GLYCOL
Engine Oil	5W-20 · API
Engine Oil Capacity	4.4 qt
Power Steering Fluid	ATF

Engine torques

Cylinder Head Steps	3
Cylinder Head Steps	3
Intake Manifold to Engine Bolts	14-22 ft-lbs
Exhaust Manifold to Cylinder Head Bolts	25-36 ft-lbs
Intake Manifold to Engine Bolts	16 ft-lbs
Exhaust Manifold to Cylinder Head Bolts	31 ft-lbs

Chassis torques

Driveshaft Flange to Transmission	Front: 27.0; Rear: 82.0 ft-lbs
Lug Nuts	65-87 ft-lbs
Transfer Case Fill Plug	22.0 ft-lbs
Transfer Case Drain Plug	22.0 ft-lbs

Ignition

Cylinder Firing Order	1-3-4-2
Cylinder Firing Order	1-2-3-4-5-6
Ignition Timing	4, Not adjustable degrees
Ignition Timing Acceptable Variance	6 degrees

Battery & A/C

Refrigerant	R134a
Oil Group	PAG
Standard BCI Group Number	58
Standard BCI Cranking Performance	470 cca

Service checks

Engine Compression	No standard
Intake Valve Lash	0.012 in
Exhaust Valve Lash	0.012 in

Brakes

Torque to Knuckle	17 ft-lbs
Minimum Pad Thickness	0.079 in
Minimum Shoe Thickness	0.039 in
Rotor Runout Limit	0.0039 in
Rotor Nominal Thickness From	0.945 in
Rotor Nominal Thickness To	0.945 in
Rotor Discard at or Under	0.882 in
Drum Nominal Diameter	9.843 in

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 7,500 mi; spark plugs every 60,000 mi.

Every 7,500 mi	Body Latches, Locks & Hinges (inspect) · Engine Oil (drain & refill) · Engine Oil Filter (replace)
Every 15,000 mi	Axle Shaft Oil Seal (inspect) · Brake System (inspect) · Transfer Case Assembly (inspect fluid level)
Every 30,000 mi	Accessory Drive Belt (inspect) · Brake Drum Assembly (inspect) · Brake Line (inspect) · CV Joint Boot (inspect) · Drive Axle Assembly (drain & refill) · Driveshaft U-Joint (lubricate)
Every 60,000 mi	Emission Control System (inspect) · PCV System (inspect) · Spark Plug Wires (inspect)
Every 90,000 mi	Timing Belt (inspect)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

The 1995 Kia Sportage serves as the introductory year of its generation, recording 67 complaints, 2 recalls, 1 investigation, and 8 TSBs, with engine and engine cooling (12), seat belts (8), and the electrical system (5) as the primary complaint categories. Looking at the generation's trend, 1995 marks the lowest complaint volume before figures escalate significantly to 217 in 1997 and peak at 383 in 1998. Its position at the start of this escalating arc implies that while early models avoided the sheer volume of reported issues seen in the late-nineties variants, the data does not specify the root causes for the subsequent surge in complaints. The 1995 model also saw minimal severe incident reports, with just 2 crash and 1 fire complaint. Consequently, while 1995 is the statistically safest bet within a generation plagued by escalating issues, it remains a risky purchase unless the engine, seat belt, and electrical systems have been thoroughly inspected and resolved.

Open recalls

NHTSA campaigns

Service bulletins

Manufacturer communications

ODI investigations

Office of Defects Investigation

Owner complaints

2 involved a crash · 1 a fire

Owner complaints by model year NHTSA · this generation & adjacent

’95’96 ’97 ’98 ’99 ’00 ’01 ’02 ’03 ’05 ’06 ’07 ’08 ’09 ’10 ’11 ’12 ’13 ’14 ’15 ’16 ’17 ’18 ’19 ’20 ’21 ’22 ’23 ’24 ’25 ’26

Owner complaints filed with NHTSA, by component

All 67 complaints on record, top 8 components.

Engine & Engine Cooling12

Seat Belts8

Electrical System5

Suspension4

Visibility4

Structure4

Vehicle Speed Control3

Service Brakes, Hydraulic3

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 2 of 2 campaigns on record for this vehicle.

02V216000Seat Belts:Front:Buckle AssemblyReported 16/08/2002

ON CERTAIN PASSENGER VEHICLES, THE SAFETY BELT BUCKLE MAY "FALSE LATCH" AND EXPOSE THE DRIVER TO UNRESTRAINED MOVEMENT DURING A CRASH. Remedy: OWNER NOTIFICATION BEGAN DECEMBER 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A…

95V073000Suspension:RearReported 11/04/1995

THE NUTS ATTACHING THE REAR AXLE BEARING OIL SEAL RETAINERS AND BRAKE BACKING PLATES TO THE REAR AXLE HOUSING MAY BE UNDER- TORQUED CAUSING THESE UNITS TO LOOSEN OR FALL OFF. Remedy: DEALERS WILL INSPECT AND RETORQUE THE REAR AXLE BEARING OIL SEAL RETAINER NUTS.

Technical service bulletins NHTSA · verified

Showing 5 of 8 bulletins on record with NHTSA.

Bulletin	Date	Component	Summary
PS539	2018-03-02	Engine And Engine Cooling	PITSTOP - ENGINE COMPONENT RE-USE GUIDELINES - In general, parts and components removed…
TSB-GEN085R1	2017-01-18	Equipment	TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners…
TSB-GEN085	2016-11-04	Latches/Locks/Linkages	TSB: MANDATORY REPLACEMENT OF LOCKING/SECURITY HARDWARE - By design, certain fasteners…
KT-2008082201	2008-08-28	Parking Brake	KIA: ALL MODELS. ARTICLE PROVIDES INFORMATION RELATING TO THE IMPROVED DURABILITY OF BULB…
76	2004-01-01	Fuel System, Other	FUEL PUMP RELAYS & EMISSIONS FAILURES. KIA TECHNICIAN TIMES. *TT

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420

Catalyst system efficiency below threshold — Bank 1

P0300

Random / multiple cylinder misfire detected

P0171

System too lean — Bank 1

P0455

Evaporative emission system leak detected — large leak

P0128

Coolant thermostat below regulating temperature

P0442

Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN

Decode a VIN to confirm the transmission and build data for a specific Sportage. OEM

Build data

Plant, GVWR class, engine and body data for any 17-character VIN.

Recalls

Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Group 58 battery Vehicles taking 4.4 qt

Reference guides

Cross-vehicle references for the kinds of data on this page.

Vehicle recalls & TSBs OBD-II trouble codes Maintenance schedules Fluid capacities & specs

Frequently asked

How much oil does the 1995 Sportage take?

4.4 qt of 5W-20 API, per the factory manual.

Does the 1995 Sportage have open recalls?

NHTSA lists 2 recall campaign(s) for this model year. Check your specific vehicle by VIN.

What gas mileage does the Sportage get?

EPA figures are 17 city / 21 highway / 19 combined mpg.