ChryslerSebring20102.4L L4/chrysler/sebring/2010/2-4l-l4/
JS platform

2010 Chrysler Sebring — 2.4L L4

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2010 Sebring 2.4L L4. Covers both the standard and High Output 2.4L L4.

Body PASSENGER CAREngine 2.4L L4Transmission Automatic 4-spd

The 2010 Chrysler Sebring is a passenger car built on the JS platform, powered by a 2.4L L4 engine paired with a 4-speed automatic transmission, and it achieves EPA fuel economy ratings of 21 city, 30 highway, and 24 combined mpg. Within the model’s complaint history spanning 1995 to 2013, the 2010 model year recorded 104 total owner complaints—far below the peak of 483 in 1996 but well above the low of 3 in 2011—along with three recalls, placing it in a middling position for reliability that researchers should note as neither the worst nor the best of the generation.

Model year20102009200620052004200320022001

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity4.5 qt w/ filterOEM · verified
Engine oil type5W-20 / 5W-30 APIOEM · verified
Lug nut torque85-115 ft-lbsOEM · verified
EPA fuel economy21/30/24 mpgEPA · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 86 · 525 CCA battery, OE oil filter 04892339BE. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 86 · 525 CCAOEM · verified
Tire sizeP215-55R18OEM · verified
Wheel / rim7 inOEM · verified

OE service part numbers OEM · verified

Engine oil filter04892339BE
Engine air filter04891713AB alt 04891926AB
Spark plugSP00ZFR5AP alt SP0ZFR5F11
BatteryBB86F101AA alt BB34A901AA
Front wiper bladesWBF00024AB alt WBF00022AB
Serpentine belt04891935AC alt 04891704AA
Thermostat68237102AA alt 55111017AB
Cabin air filter05058693AA

Full specifications

Engine, drivetrain, dimensions and economy.

Engine & drivetrain NHTSA vPIC

TransmissionAutomatic 4-spd

Dimensions & weight NHTSA vPIC

Overall length193.7 in
Overall width71.7 in
Overall height58.7 in
Wheelbase109.1 in
Curb weight3957 lb
Track (front / rear)61 / 61.4 in
Weight distribution (front / rear)61/39

Ratings & economy EPA / vPIC

EPA city / highway / combined21 / 30 / 24 mpg
DrivetrainFront-Wheel Drive
Passenger volume101 cu ft
Cargo volume14 cu ft
Recommended fuelRegular Gasoline

Performance & power Independent road tests

0–60 mph, quarter-mile, horsepower and torque from independent road tests.

No 2010 road test on record; the results below are same-engine tests from nearby model years, each shown under its own year.

9.5 sec0–60 mph (tested)quickest 9.50 sec — 2007 Touring Sedan
173 hpHorsepower (as tested)
166 lb-ftTorque (as tested)
YearTrim / engine0–60¼ mileHPDrivetrain
2007Touring Sedan 2.4L I-49.50 sec17.30 sec173 hpFWD

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 4.5 qt w/ filter of 5W-20 / 5W-30 API engine oil, DOT 3 brake fluid. Torque lug nuts to 85-115 ft-lbs, the oil drain plug to 21.0 ft-lbs. The firing order is 1-3-4-2.

Lubricants & capacities

Automatic Transmission FluidATF+4
Automatic Transmission Fluid Capacity5
Brake FluidDOT 3
Engine Oil5W-20 · API · 5W-30 · MS-6395
Engine Oil Capacity4.5 qt w/ filter

Engine torques

Camshaft Bearing/Carrier Cap Bolts or StudsM6 Bolts: 9 ft-lbs, M8 Bolts: 22 ft-lbs
Crankshaft Pulley and/or Damper Bolts155 ft-lbs
Intake Manifold to Engine Bolts18.4 ft-lbs
Exhaust Manifold to Cylinder Head Bolts25 ft-lbs
Engine Oil Pan Drain Plug21.0 ft-lbs

Chassis torques

Lug Nuts85-115 ft-lbs
Front Wheel Hub118 ft-lbs
Rear Wheel Hub181 ft-lbs

Ignition

Cylinder Firing Order1-3-4-2
Ignition Coil Primary Resistance.504-.616 ohms
Ignition Coil Secondary Resistance5220-6380 ohms
Spark Plug ManufacturerChampion
Spark Plug GapWithout PZEV: 0.043, With PZEV: 0.031 in
Spark Plug Torque20.0 ft-lbs

Battery & A/C

RefrigerantR134a
Refrigerant Capacity1.00 lbs
Oil GroupPAG
Oil Type46
Oil Capacity3.40 oz
Standard BCI Group Number86
Standard BCI Cranking Performance525 cca

Service checks

Pressure Test15 psi
Radiator Cap Pressure Relief14-18 psi
Thermostat Opening TemperaturePrimary: 179, Secondary: 203 °F
Regulated Fuel System Pressure (With Vacuum)58.0 + or - 5.0 psi
Injector Primary Resistance12 approx. @ 68 degreesF ohms
Engine Compression170
Engine Oil Pressure25-80 psi
Engine Oil Pressure RPM3000 rpm

Brakes

Torque Caliper to Bracket32 ft-lbs
Torque to Knuckle52 ft-lbs / 80 ft-lbs
Minimum Pad ThicknessFront: 0.040; Rear: 0.040 in
Rotor Max Parallel Variation0.0006 in / 0.0002 in
Rotor Runout Limit0.0024 in / 0.0016 in / 0.002 in
Rotor Nominal Thickness From0.386 in / 1.02 in
Rotor Nominal Thickness To0.402 in / 1.028 in
Rotor Discard at or Under0.331 in / 0.961 in

Multi-step torque procedures OEM · verified

Connecting Rod (Large End) Bearings — tightening sequence 1 stages
115 ft. lbs., Step 2: 9015 ft. lbs
Cylinder Head — tightening sequence 1 stages
145.0 ft. lbs. Step 2: 65.0 ft. lbs. Step 3: 65.0 ft. lbs. Step 4: 90 degreesCAUTION:Do not use a torque wrench for the Fourth step. Bolts should be checked for stretching using a straight edge. Ay bolts that show stretching should be replaced.45 ft. lbs
Engine Flywheel Bolts — tightening sequence 1 stages
122 ft. lbs., Step 2: 5122 ft. lbs
Main Bearings — tightening sequence 1 stages

Prep Bolts stamped with the letter B or the number 6 use the following torque procedure.

111 ft. lbs., Step 2: 20 ft. lbs., Step 3: 45 degrees; Bolts that are not stamped with the letter B or the number 6 use the following torque procedure.11 ft. lbs
111 ft. lbs., Step 2: 33 ft. lbs., Step 3: 45 degrees11 ft. lbs

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 6,000 mi; spark plugs every 60,000 mi; coolant at 102,000 mi. The big-interval services (at 102,000 mi for coolant, and the transmission fluid) are the ones owners most often skip — on a lower-mileage example, assume the original fluids are still in it and check them first.

Every 6,000 miEngine Oil (drain & refill) · Engine Oil Filter (replace) · Tire & Wheel Assembly (rotate)
Every 12,000 miBrake Linings (inspect) · CV Joint Boot (inspect) · Cabin Air Filter (replace) · Exhaust System (Complete) (inspect) · Suspension System (inspect) · Tie Rod (inspect)
Every 30,000 miEngine Air Filter Element (replace)
Every 60,000 miSpark Plugs (replace)
Every 90,000 miPCV Valve (inspect)
At 102,000 miAccessory Drive Belt (inspect) · Engine Coolant System (drain, flush & refill)
At 120,000 miTransmission Fluid & Filter (replace)

Owner how-tos

Condensed service procedures for routine maintenance. Procedures that require dealer diagnostic equipment are identified and summarized only.

Common procedures

Key fob — remote (RKE) programming programming new fob buttons Dealer tool OEM · verified
Tool requiredDRBIII scan tool (dealer / locksmith)
WhyTransmitter codes are written into the receiver in the passenger door module
Anti-theft (SKIS) — module initialization after immobilizer module replacement Dealer tool OEM · verified
When neededAfter Sentry Key Immobilizer Module (SKIM) replacement
Tool requiredDRBIII scan tool
Also requiredThe vehicle's four-digit PIN code

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

The 2010 Chrysler Sebring generated 104 federal complaints, three recalls, and zero investigations, placing it above the 2009 low of 45 complaints but well below the 2007-2008 generation peak that saw 339 and 352 complaints respectively. Across this generation, the federal record shows a sharp escalation in 2007-2008 followed by a steep decline, with 2010 representing a late-phase rebound before complaints essentially collapsed to three in 2011 and zero by 2012. For this specific year, the leading complaint categories were “Air Bags,Seat Belts” with 16 filings, “Air Bags” with 12, Engine with 9, and Service Brakes with 6, alongside 8 crash complaints and 5 fire complaints, though the data does not specify underlying causes. Because 2010 carries notably more federal complaints than the immediately preceding and following years while still showing significant safety-system filings, it sits in a weaker position within the generation’s downward trend. The concrete takeaway is that while 2010 avoids the worst complaint volumes of 2007-2008, the elevated air bag and seat belt reports combined with its late-generation timing make it a cautiously mediocre choice rather than a standout year to buy.

3
Open recalls
NHTSA campaigns
61
Service bulletins
Manufacturer communications
0
ODI investigations
Office of Defects Investigation
104
Owner complaints
8 involved a crash · 5 a fire
Owner complaints by model year NHTSA · this generation & adjacent

Owner complaints filed with NHTSA, by component

All 104 complaints on record, top 8 components.

Air Bags,Seat Belts16
Air Bags12
Engine9
Service Brakes6
Electrical System6
Power Train4
Power Train,Vehicle Speed Control3
Structure3

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 2 of 3 campaigns on record for this vehicle.

16V668000Seat Belts:PretensionerReported 15/09/2016

Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control… Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016…

10V475000Steering:Electric Power Assist SystemReported 07/10/2010

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 CHRYSLER SEBRING, 300, CHARGER (LX) AND DODGE CHALLENGER (LC), AVENGER (JS), AND JOURNEY (JC), AS WELL AS MODEL YEAR 2011 DODGE RAM LIGHT DUTY PICKUP (DS) VEHICLES. SOME OF… Remedy: DEALERS WILL INSPECT AND REPLACE AS NECESSARY THE POWER STEERING PRESSURE HOSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 20, 2010. OWNERS MAY CONTACT CHRYSLER AT…

Technical service bulletins NHTSA · verified

Showing 5 of 61 bulletins on record with NHTSA.

BulletinDateComponentSummary
1040872025-04-02Unknown Or OtherACTUATOR - A/C AND HEATER
91002262023-09-15Electrical SystemConnector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar…
91002262023-09-15Electrical SystemConnector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar…
91001962023-07-27EquipmentLubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily…
S22090000042022-04-02Engine And Engine CoolingIf a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420
Catalyst system efficiency below threshold — Bank 1
P0300
Random / multiple cylinder misfire detected
P0171
System too lean — Bank 1
P0455
Evaporative emission system leak detected — large leak
P0128
Coolant thermostat below regulating temperature
P0442
Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN
Decode a VIN to confirm the transmission and build data for a specific Sebring. OEM
Build data
Plant, GVWR class, engine and body data for any 17-character VIN.
Recalls
Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Reference guides

Cross-vehicle references for the kinds of data on this page.

Frequently asked

How much oil does the 2010 Sebring 2.4L L4 take?

4.5 qt w/ filter of 5W-20 API OR 5W-30 API MEETING CHRYSLER SPECIFICATION MS-6395, per the factory manual.

Does the 2010 Sebring have open recalls?

NHTSA lists 3 recall campaign(s) for this model year. Check your specific vehicle by VIN.

What gas mileage does the 2.4L L4 get?

EPA figures are 21 city / 30 highway / 24 combined mpg.