VolvoS90L2017Overview/volvo/s90l/2017/base/

2017 Volvo S90L

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2017 S90L.

Body SUVTransmission Automatic (S8)

The 2017 Volvo S90L is an SUV that mates an automatic S8 transmission with an EPA‑rated fuel economy of 22 mpg city, 31 mpg highway and 25 mpg combined. Owner reports for the year total eight complaints, with the leading issue listed as “Unknown Or Other,” and the vehicle was subject to four recalls. These figures constitute the initial reliability snapshot for the 2017 S90L, placing it at the start of the model’s documented history. The modest complaint count and limited recall number indicate a relatively trouble‑free introduction for the nameplate.

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Lug nut torque103 ft-lbsOEM · verified
EPA fuel economy22/31/25 mpgEPA · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 94R; AUXILIARY FOR STOP START: N/A · 800; AUXILIARY FOR STOP START: 170 CCA battery, OE oil filter 32140029. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 94R; AUXILIARY FOR STOP START: N/A · 800; AUXILIARY FOR STOP START: 170 CCAOEM · verified
Tire sizeP245/45R18, P255/40R19, P255/35R20, P245/35R21OEM · verified
Wheel / rimNS inOEM · verified

OE service part numbers OEM · verified

Engine oil filter32140029
Engine air filter31370089
Fuel filter32242191
Battery31419211
Front wiper blades32341610
Thermostat31368063 alt 31686560
Cabin air filter31407748

Diagrams

Power distribution wiring8 sheets

Full specifications

Engine, drivetrain, dimensions and economy.

Engine & drivetrain NHTSA vPIC

TransmissionAutomatic (S8)

Ratings & economy EPA / vPIC

EPA city / highway / combined22 / 31 / 25 mpg
DrivetrainAll-Wheel Drive
Passenger volume98 cu ft
Cargo volume14 cu ft
Recommended fuelPremium Gasoline

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

Torque lug nuts to 103 ft-lbs. The firing order is 1-3-4-2. Note the cylinder-head bolts finish on a torque angle (torque-to-yield) — they stretch permanently and should be replaced, not reused, during any head service.

Engine torques

Crankshaft Position (CKP) Sensor Bolt(s)12.5 ft-lbs
Camshaft Position (CMP) Sensor Bolt(s)7.3 ft-lbs
Camshaft Bearing/Carrier Cap Bolts or Studs13.0 ft-lbs
Engine Coolant Temperature (ECT) Sensor Bolt(s)16.2 ft-lbs
Oxygen (O2S) Sensor Bolt(s)33.1 ft-lbs
Knock Sense (KS) Bolt(s)17.4 ft-lbs
Intake Manifold to Engine Bolts13
Exhaust Manifold to Cylinder Head Bolts15

Chassis torques

Lug Nuts103 ft-lbs

Ignition

Cylinder Firing Order1-3-4-2
Ignition Coil Primary Resistance350 ohms
Spark Plug ManufacturerVolvo
Spark Plug Torque13.0 ft-lbs

Battery & A/C

RefrigerantR134a
Oil GroupPAG
Standard BCI Group Number94R; AUXILIARY FOR STOP START: N/A
Standard BCI Cranking Performance800; AUXILIARY FOR STOP START: 170 cca
Optional BCI Group Number49
Optional BCI Cranking Performance850 cca

Brakes

Minimum Pad ThicknessFront: 0.079; Rear: 0.079 in
Vented Rotor Minimum Thickness after RefinishStamped on rotor

Multi-step torque procedures OEM · verified

Front Wheel Hub — tightening sequence 1 stages
126.0.0 ft. lbs., 90
Rear Wheel Hub — tightening sequence 1 stages
126.0.0 ft. lbs., 90
Connecting Rod (Large End) Bearings — tightening sequence 3 stages
111.0 ft. lbs.11 ft. lbs
218.0 ft. lbs.18 ft. lbs
390.0
Crankshaft Pulley and/or Damper Bolts — tightening sequence 4 stages
115.0 ft. lbs. Screw to crankshaft15 ft. lbs
2+ 90 degrees90 degrees
381.0 ft. lbs. Center bolt81 ft. lbs
4+ 90
Cylinder Head — tightening sequence 3 stages

Prep Do not reuse old bolts. Use new bolts coated with clean engine oil. Tighten all bolts to finger tight then continue on with the following procedure.

133.0 ft. lbs.33 ft. lbs
2120 degrees120 degrees
3120 degrees120 degrees
Engine Flywheel Bolts — tightening sequence 2 stages
133.0 ft. lbs.33 ft. lbs
250.0
Main Bearings — tightening sequence 4 stages
1Inner bolts15 ft. lbs
2Inner bolts30 ft. lbs
3Outer bolts18 ft. lbs
490.0

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 10,000 mi; spark plugs every 60,000 mi; coolant every 10,000 mi. The big-interval services (every 10,000 mi for coolant, and the transmission fluid) are the ones owners most often skip — on a lower-mileage example, assume the original fluids are still in it and check them first.

At 3,000 miTire & Wheel Assembly (rotate)
Every 6,000 miTire & Wheel Assembly (rotate)
Every 10,000 miBrake Linings (inspect) · Brake Rotor (inspect) · Engine Coolant System (inspect fluid level) · Engine Oil (drain & refill) · Engine Oil Filter (replace) · Exterior Lighting (inspect)
Every 20,000 miCabin Air Filter (replace) · Engine Assembly (leak inspection) · Headlamp (inspect alignment)
Every 40,000 miBrake Hydraulic System (drain, refill & bleed) · Brake Line (inspect) · CV Joint Boot (inspect) · Driveshaft (inspect) · Driveshaft U-Joint (inspect) · Engine Air Filter Element (replace)
Every 50,000 miTransmission Assembly (inspect fluid level)
Every 60,000 miSpark Plugs (replace)
At 150,000 miDrive Belt (replace) · Timing Belt Tensioner (replace)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

Owner complaints about the 2017 Volvo S90L dominate in one area — the unknown or other, 4 of 8 reports (50%), well ahead of the next concern. NHTSA has issued no recalls for this vehicle, so these are owner-reported concerns only. 1 of the reports describe a crash and 0 a fire — a small share of the total, but worth weighing against the unknown or other pattern above. These are tallies of what owners actually reported to the federal government, not an editorial score — and higher-selling models naturally rack up more reports.

4
Open recalls
NHTSA campaigns
525
Service bulletins
Manufacturer communications
0
ODI investigations
Office of Defects Investigation
8
Owner complaints
1 involved a crash · 0 a fire

Owner complaints filed with NHTSA, by component

All 8 complaints on record, top 5 components.

Unknown Or Other4
Suspension1
Structure1
Fuel/Propulsion System1
Power Train1

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

No recall campaigns on record with NHTSA for this vehicle as of the last data refresh.

Technical service bulletins NHTSA · verified

Showing 5 of 525 bulletins on record with NHTSA.

BulletinDateComponentSummary
85012025-04-10Exterior LightingThis is a Technical Journal: Remote connection, BOMGAR application. Before joining a…
369612025-03-18Electrical SystemThis is a Technical Journal: Improved 12V battery test in VIDA. Service:
 Don´t…
372352025-02-28Exterior LightingThis is a Technical Journal: Changed front fog/cornering lights behavior. This logic of…
S103032025-02-21Unknown Or OtherVolvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has…
S103032025-02-13Unknown Or OtherVolvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420
Catalyst system efficiency below threshold — Bank 1
P0300
Random / multiple cylinder misfire detected
P0171
System too lean — Bank 1
P0455
Evaporative emission system leak detected — large leak
P0128
Coolant thermostat below regulating temperature
P0442
Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN
Decode a VIN to confirm the transmission and build data for a specific S90L. OEM
Build data
Plant, GVWR class, engine and body data for any 17-character VIN.
Recalls
Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Fuse box & wiring diagrams

Interactive fuse-box and wiring references for this vehicle, searchable by circuit.

Reference guides

Cross-vehicle references for the kinds of data on this page.

Frequently asked

Does the 2017 S90L have open recalls?

NHTSA lists 4 recall campaign(s) for this model year. Check your specific vehicle by VIN.

What gas mileage does the S90L get?

EPA figures are 22 city / 31 highway / 25 combined mpg.