VolvoS902020Overview/volvo/s90/2020/base/

2020 Volvo S90

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2020 S90.

Transmission Automatic (S8)

The 2020 Volvo S90 arrives as a midsize executive sedan equipped with an automatic S8 gearbox and delivers a combined fuel economy of 21 mpg city, 31 mpg highway and 25 mpg combined. Owner feedback for this year is exceptionally low, with only a single complaint recorded and two recalls noted, the most frequent issue being related to suspension, wheels and service brakes. Compared with the model’s broader history—spanning 1997‑2016 and ranging from a peak of 39 complaints in 1998 to a low of one in 1999—the 2020 iteration sits at the very bottom of the complaint spectrum, indicating a strong reliability standing for this generation.

Model year202520242023202220212020201920182017

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Lug nut torque103 ft-lbsOEM · verified
EPA fuel economy21/31/25 mpgEPA · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses OE oil filter 32140029. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Tire size255/40R19/XL 100VOEM · verified
Wheel / rim8.5 inOEM · verified

OE service part numbers OEM · verified

Engine oil filter32140029
Engine air filter31370089
Battery30659531 alt 31652065
Front wiper blades32341610
Thermostat31368063 alt 31686046
Cabin air filter31407747 alt 31407748

Full specifications

Engine, drivetrain, dimensions and economy.

Engine & drivetrain NHTSA vPIC

TransmissionAutomatic (S8)

Dimensions & weight NHTSA vPIC

Overall length200.4 in
Overall width74.4 in
Overall height56.7 in
Wheelbase120.5 in
Curb weight4057 lb
Track (front / rear)64.2 / 64.2 in
Weight distribution (front / rear)56/44

Ratings & economy EPA / vPIC

EPA city / highway / combined21 / 31 / 25 mpg
DrivetrainAll-Wheel Drive
Passenger volume102 cu ft
Cargo volume14 cu ft
Recommended fuelPremium Gasoline

Performance & power Independent road tests

0–60 mph, quarter-mile, horsepower and torque from independent road tests.

Independent road tests for the S90 of this era, listed by trim and engine — this page spans more than one engine, so no single horsepower figure is shown.

4.5–6.5 sec0–60 mph (tested)quickest 4.50 sec — 2018 T8 Inscription Plug-In Hybrid Sedan
YearTrim / engine0–60¼ mileHPDrivetrain
2021Recharge T8 Inscription Sedan 2.0L Turbo Supercharger I-4 + Elec 11.6-kWh4.70 sec13.30 sec400 hpAWD
2021Recharge T8 Inscription Sedan 2.0L Turbo Supercharger 1-4 + Elec 11.6-kWh4.90 sec13.50 sec400 hpAWD
2018T8 Inscription Plug-In Hybrid Sedan 2.0L Turbo Supercharger I-4 + Elec 10.4-kWh4.50 sec13.30 sec400 hpAWD
2018T6 Inscription Sedan 2.0L Turbo Supercharger I-45.90 sec14.50 sec316 hpAWD
2022B6 R-Design Sedan 2.0L Turbo Supercharger I-46.40 sec14.80 sec295 hpAWD
2017T6 Inscription Sedan 2.0L Turbo Supercharger I-45.60 sec14.10 sec316 hpAWD
2017T6 Inscription Sedan 2.0L Turbo Supercharger I-45.60 sec14.10 sec316 hpAWD
2017T6 Inscription Sedan 2.0L Turbo Supercharger I-45.60 sec14.10 sec316 hpAWD

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

Torque lug nuts to 103 ft-lbs.

Engine torques

Camshaft Bearing/Carrier Cap Bolts or Studs13.0 ft-lbs

Chassis torques

Lug Nuts103 ft-lbs
Lug Nuts103 ft-lbs

Battery & A/C

RefrigerantR1234yf
Refrigerant Capacity1.38 lbs
Oil GroupPAG
Oil Type46YF
Oil Capacity2.03 oz

Brakes

Brake Caliper Bolt to Carrier TorqueFront: 42.0 ft-lbs; Rear: 21.0 ft-lbs
ABS Sensor TorqueFront: 6.0; Rear: 6.0
Vented Rotor Minimum Thickness for ReplacementRear: .374
Vented Rotor Minimum Thickness after RefinishRear: .425
Maximum Rotor RunoutFront: .0016; Rear: .003

Multi-step torque procedures OEM · verified

Connecting Rod (Large End) Bearings — tightening sequence 1 stages
111.0 ft. lbs., Step 2: 18.0 ft. lbs., Step 3: 90°11 ft. lbs
Engine Flywheel Bolts — tightening sequence 1 stages
133.0 ft. lbs., Step 2: 50°33 ft. lbs
Main Bearings — tightening sequence 1 stages
1Inside Bolts15 ft.lbs

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 10,000 mi; spark plugs every 60,000 mi; coolant every 10,000 mi. The big-interval services (every 10,000 mi for coolant, and the transmission fluid) are the ones owners most often skip — on a lower-mileage example, assume the original fluids are still in it and check them first.

Every 10,000 miBrake Linings (inspect) · Brake Rotor (inspect) · Engine Coolant System (inspect fluid level) · Engine Oil (drain & refill) · Engine Oil Filter (replace) · Exterior Lighting (inspect)
Every 20,000 miCabin Air Filter (replace) · Engine Assembly (leak inspection) · Foglamp (adjust alignment) · Headlamp (inspect alignment)
Every 40,000 miBrake Hydraulic System (drain, refill & bleed) · Brake Line (inspect) · CV Joint Boot (inspect) · Drive Axle Assembly (inspect) · Driveshaft (inspect) · Driveshaft U-Joint (inspect)
Every 50,000 miTransmission Assembly (inspect fluid level)
Every 60,000 miSpark Plugs (replace)
At 150,000 miDrive Belt (replace) · Timing Belt Tensioner (replace)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

The 2020 Volvo S90 sits within a generation that began in 2016, where the federal record shows 0 complaints and 2 recalls for that inaugural year. The only data point for the 2020 model year is a single complaint categorized under Suspension, Wheels, and Service Brakes, with no crash or fire complaints reported. This continues the low complaint volume seen in 2016, a stark contrast to the earlier 1997–1999 generation, which accumulated up to 39 complaints and multiple investigations. The absence of recall or investigation data for 2020 in the provided record means the data doesn't specify whether any recalls were issued, but the minimal complaint activity suggests no widespread systemic issues emerged. Overall, the 2020 S90 appears to be a reliable choice within this generation, though a prospective buyer should verify any open recalls through a dealer.

2
Open recalls
NHTSA campaigns
199
Service bulletins
Manufacturer communications
0
ODI investigations
Office of Defects Investigation
1
Owner complaints
0 involved a crash · 0 a fire
NHTSA crash-test rating federal NCAP · out of 5 stars
Overall★★★★
Frontal★★★★★
Side★★★★★
Rollover★★★★★
Owner complaints by model year NHTSA · this generation & adjacent

Owner complaints filed with NHTSA, by component

All 1 complaints on record, top 1 components.

Suspension,Wheels,Service Brakes1

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

No recall campaigns on record with NHTSA for this vehicle as of the last data refresh.

Technical service bulletins NHTSA · verified

Showing 5 of 199 bulletins on record with NHTSA.

BulletinDateComponentSummary
85012025-04-10Exterior LightingThis is a Technical Journal: Remote connection, BOMGAR application. Before joining a…
369612025-03-18Electrical SystemThis is a Technical Journal: Improved 12V battery test in VIDA. Service:
 Don´t…
372352025-02-28Exterior LightingThis is a Technical Journal: Changed front fog/cornering lights behavior. This logic of…
S103032025-02-21Unknown Or OtherVolvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has…
S103032025-02-13Unknown Or OtherVolvo Cars USA LLC and Volvo Car Canada LTD on behalf of the Volvo Car Corporation has…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420
Catalyst system efficiency below threshold — Bank 1
P0300
Random / multiple cylinder misfire detected
P0171
System too lean — Bank 1
P0455
Evaporative emission system leak detected — large leak
P0128
Coolant thermostat below regulating temperature
P0442
Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN
Decode a VIN to confirm the transmission and build data for a specific S90. OEM
Build data
Plant, GVWR class, engine and body data for any 17-character VIN.
Recalls
Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Reference guides

Cross-vehicle references for the kinds of data on this page.

Frequently asked

Does the 2020 S90 have open recalls?

NHTSA lists 2 recall campaign(s) for this model year. Check your specific vehicle by VIN.

What gas mileage does the S90 get?

EPA figures are 21 city / 31 highway / 25 combined mpg.