Volkswagen›Jetta Sedan›2007›Overview/volkswagen/jetta-sedan/2007/base/

2007 Volkswagen Jetta Sedan

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2007 Jetta Sedan.

Body PASSENGER CAR

The 2007 Volkswagen Jetta Sedan presents as a passenger car with a 6.3-quart oil capacity accepting 0W-40, 5W-30, or 5W-40 viscosity grades, specifications that frame its maintenance baseline. Its reliability record shows 201 owner complaints logged, with service brakes and hydraulic systems emerging as the leading concern, alongside six recalls issued for the model year. That complaint volume and brake-focused pattern position this generation as a chapter where hydraulic brake integrity warrants particular attention from researchers evaluating long-term ownership prospects.

Model year2011 2007 2006 2005 2004 2003

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity6.3 qtOEM · verified

Engine oil type0W-40 / 5W-30 / 5W-40OEM · verified

Lug nut torque89 ft-lbsOEM · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 47 · 540 CCA battery, OE oil filter 06D115562. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 47 · 540 CCAOEM · verified

OE service part numbers OEM · verified

Engine oil filter	06D115562
Engine air filter	06F133843A alt 07K129620
Fuel filter	6Q0201051J alt 1K0201051K
Spark plug	06H905601A alt 101905600C
Battery	000915105AD alt 000915105AF
Front wiper blades	1Q1998002
Serpentine belt	07K145933C alt 07K145933E
Thermostat	07K121113B alt 07K121119A
Cabin air filter	1K1819669

Full specifications

Engine, drivetrain, dimensions and economy.

Dimensions & weight NHTSA vPIC

Overall length	172.4 in
Overall width	68.5 in
Overall height	57.1 in
Wheelbase	98.8 in
Curb weight	2895 lb
Track (front / rear)	59.8 / 58.7 in
Weight distribution (front / rear)	60/40

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 6.3 qt of 0W-40 / 5W-30 / 5W-40 engine oil, FINAL DRIVE W/01M: USE AUDI PART NO. G052145 in the differential, DOT 4 brake fluid. Torque lug nuts to 89 ft-lbs. The firing order is 1-2-4-5-3. Note the cylinder-head bolts finish on a torque angle (torque-to-yield) — they stretch permanently and should be replaced, not reused, during any head service.

Lubricants & capacities

Automatic Transmission Fluid	ATF
Automatic Transmission Fluid Capacity	6.5-7.5
Brake Fluid	DOT 4
Differential Gear Oil	FINAL DRIVE W/01M: USE AUDI PART NO. G052145
Differential Gear Oil Capacity	1.7 Pints
Engine Coolant	USE G012ABG-A1 COOLANT
Engine Oil	0W-40 · 5W-30 · 5W-40
Engine Oil Capacity	6.3 qt

Engine torques

Camshaft Bearing/Carrier Cap Bolts or Studs	11 ft-lbs
Intake Manifold to Engine Bolts	7.3 ft-lbs
Exhaust Manifold to Cylinder Head Bolts	15 ft-lbs
Intake Manifold to Engine Bolts	7.3 ft-lbs
Exhaust Manifold to Cylinder Head Bolts	18 ft-lbs

Chassis torques

Lug Nuts

89 ft-lbs

Ignition

Cylinder Firing Order	1-3-4-2
Cylinder Firing Order	1-2-4-5-3
Curb Idle Speed (No Load)	720 rpm
Curb Idle Speed Variance (No Load)	80 rpm
Curb Idle Speed (No Load)	700 rpm
Curb Idle Speed Variance (No Load)	20 rpm

Battery & A/C

Refrigerant	R134a
Refrigerant Capacity	1.10-1.21 lbs
Oil Group	PAG
Oil Type	46
Oil Capacity	3.38-4.05 oz
Standard BCI Group Number	47
Standard BCI Cranking Performance	540 cca
Optional BCI Group Number	94R

Service checks

Fuel Pump Pressure Minimum	58.0 psi
Residual Pressure	43.5 psi
Injector Primary Resistance	12-20 ohms
Injector Primary Resistance	12-20 ohms
Engine Compression	145
Engine Compression	130

Brakes

Brake Application	WITH FS III
Torque to Knuckle	18 ft-lbs
Torque Caliper to Bracket	18 ft-lbs / 26 ft-lbs
Minimum Pad Thickness	Front: 0.276; Rear: 0.276 specification
Brake Application	WITH FS III
Rotor Nominal Thickness From	0.866 in
Rotor Nominal Thickness To	0.866 in
Rotor Discard at or Under	0.784 in

Multi-step torque procedures OEM · verified

Camshaft Bearing/Carrier Cap Bolts or Studs — tightening sequence 1 stages

6 ft. lbs., Step 2: 90

6 ft. lbs

Connecting Rod (Large End) Bearings — tightening sequence 1 stages

22 ft. lbs., Step 2: 90

22 ft. lbs

Crankshaft Pulley and/or Damper Bolts — tightening sequence 1 stages

7 ft. lbs., step 2: 90

7 ft. lbs

Crankshaft Pulley and/or Damper Bolts — tightening sequence 1 stages

37 ft. lbs., step 2: 90

37 ft. lbs

Cylinder Head — tightening sequence 3 stages

1	29.5 ft. lbs.	29.5 ft. lbs
2	turn 90 degrees	90 degrees
3	turn 90 degrees; Do not re-use bolts.	90 degrees

Engine Flywheel Bolts — tightening sequence 1 stages

44 ft. lbs., Step 2: 90

44 ft. lbs

Engine Flywheel Bolts — tightening sequence 1 stages

44 ft. lbs., Step 2: 90

44 ft. lbs

Main Bearings — tightening sequence 1 stages

29 ft. lbs., Step 2: 90

29 ft. lbs

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter at 5,000 mi.

At 5,000 mi	Brake Hydraulic System (inspect fluid level) · Engine Oil (drain & refill) · Engine Oil Filter (replace)
Every 5,000 mi	Brake System (inspect)
Every 10,000 mi	Brake Hydraulic System (inspect fluid level) · Brake Shift Interlock Solenoid (inspect) · Engine Oil (drain & refill) · Engine Oil Filter (replace) · Neutral Safety Switch (test) · Tire & Wheel Assembly (rotate)
At 20,000 mi	Brake Hydraulic System (inspect fluid level) · Engine Oil (drain & refill) · Engine Oil Filter (replace)
Every 20,000 mi	Battery (inspect) · CV Joint Boot (inspect) · Door Stop (lubricate) · Driveshaft (inspect) · Engine Assembly (leak inspection) · Engine Coolant System (inspect fluid level)
Every 40,000 mi	Accessory Drive Belt (inspect) · Cabin Air Filter (replace) · Engine Air Filter Housing (clean) · Exterior Lighting (inspect) · Final Drive (inspect fluid level) · Power Steering System (inspect fluid level)
Every 60,000 mi	Engine Air Filter Element (replace)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

Owner complaints about the 2007 Volkswagen Jetta Sedan top in one area — the service brakes, hydraulic, 29 of 201 reports (14%), well ahead of the next concern. That matters, because the service brakes, hydraulic are also the target of recall 20E-064 on this vehicle — so the single most useful check before buying or servicing one is confirming it was actually performed. 11 of the reports describe a crash and 7 a fire — a small share of the total, but worth weighing against the service brakes, hydraulic pattern above. These are tallies of what owners actually reported to the federal government, not an editorial score — and higher-selling models naturally rack up more reports.

Open recalls

NHTSA campaigns

510

Service bulletins

Manufacturer communications

ODI investigations

Office of Defects Investigation

201

Owner complaints

11 involved a crash · 7 a fire

NHTSA crash-test rating federal NCAP · out of 5 stars

Rollover★★★★★

Owner complaints filed with NHTSA, by component

All 201 complaints on record, top 8 components.

Service Brakes, Hydraulic29

Power Train22

Air Bags20

Electrical System14

Engine8

Seats7

Engine & Engine Cooling6

Electrical System,Latches/Locks/Linkages6

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 2 of 6 campaigns on record for this vehicle.

19V679000Unknown Or OtherReported 25/09/2019

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015… Remedy: Volkswagen will notify owners and repurchase the affected vehicles. The recall began November 6, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298…

20E064000Service Brakes, Hydraulic:Foundation Components:Master CylinderReported 23/09/2020

Tenneco Automotive (Tenneco) is recalling certain Beck/Arnley Master Cylinders, part number 072-9831, sold as aftermarket or replacement parts for 2004-2018 Volkswagen Jetta, and 2012-2019 Volkswagen Beetle vehicles… Remedy: Beck/Arnley will notify the distributors that sold the master cylinders and will work with the distributors to notify the end users. Affected master cylinders will be exchanged…

Technical service bulletins NHTSA · verified

Showing 5 of 510 bulletins on record with NHTSA.

Bulletin	Date	Component	Summary
V171901201285565	2023-08-21	Engine And Engine Cooling	Update to Volkswagen engine oil standards
V171901201285562	2023-05-30	Engine And Engine Cooling	Volkswagen Engine oil quality standards, update to attachments.
V171901201285560	2023-04-24	Engine And Engine Cooling	Engine oil quality standards, update to attachments.
V941901201152119	2022-12-12	Equipment	Update model year applicability to include 2023.
V171901201285556	2022-12-12	Engine And Engine Cooling	Engine Oil Quality Standards updated to include the latest Engine Oil attachments…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420

Catalyst system efficiency below threshold — Bank 1

P0300

Random / multiple cylinder misfire detected

P0171

System too lean — Bank 1

P0455

Evaporative emission system leak detected — large leak

P0128

Coolant thermostat below regulating temperature

P0442

Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN

Decode a VIN to confirm the transmission and build data for a specific Jetta Sedan. OEM

Build data

Plant, GVWR class, engine and body data for any 17-character VIN.

Recalls

Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Group 47 battery Vehicles taking 6.3 qt Engine oil filter 06D115562 Engine air filter 06F133843A Fuel filter 6Q0201051J Spark plug 06H905601A

Reference guides

Cross-vehicle references for the kinds of data on this page.

Vehicle recalls & TSBs OBD-II trouble codes Torque specifications Maintenance schedules Fluid capacities & specs

Frequently asked

How much oil does the 2007 Jetta Sedan take?

6.3 qt of 0W-40, 5W-30 OR 5W-40 MEETING VW SPECIFICATION 502.00, per the factory manual.

Does the 2007 Jetta Sedan have open recalls?

NHTSA lists 6 recall campaign(s) for this model year. Check your specific vehicle by VIN.