ToyotaYaris2020Overview/toyota/yaris/2020/base/

2020 Toyota Yaris

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2020 Yaris.

Transmission Automatic (S6)

The 2020 Toyota Yaris features an Automatic (S6) transmission and delivers an EPA-rated 32/40/35 mpg. In the context of the 2006-2020 model history, this year recorded 9 total owner complaints and one recall, a significant decrease from the 296 complaints seen in 2007. While the gasoline fuel system is the top complaint area, the model year remains near the low end of the historical complaint range.

Model year202520242023202220202019201820172016

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Lug nut torqueHatchback: 76 ft-lbs; Sedan: 80-108 ft-lbsOEM · verified
EPA fuel economy32/40/35 mpgEPA · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 35 · 355 CCA battery, OE oil filter 90118WBA40. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 35 · 355 CCAOEM · verified
Tire sizeP185/65R15 86HOEM · verified
Wheel / rim5.5 inOEM · verified

OE service part numbers OEM · verified

Engine oil filter90118WBA40
Engine air filter17801WB001
Fuel filter77024WB001 alt 23217WB001
Spark plug90118WBC16
Front wiper blades85212WB002 alt 85212WB001
Serpentine belt90118WB464 alt 90118WBA55
Thermostat90118WB459
Cabin air filter87139WB001

Full specifications

Engine, drivetrain, dimensions and economy.

Engine & drivetrain NHTSA vPIC

TransmissionAutomatic (S6)

Dimensions & weight NHTSA vPIC

Overall length161.8 in
Overall width66.9 in
Overall height59.1 in
Wheelbase101.2 in
Curb weight2359 lb
Track (front / rear)58.3 / 57.9 in
Weight distribution (front / rear)61/39

Ratings & economy EPA / vPIC

EPA city / highway / combined32 / 40 / 35 mpg
DrivetrainFront-Wheel Drive
Passenger volume86 cu ft
Cargo volume13 cu ft
Recommended fuelRegular Gasoline

Performance & power Independent road tests

0–60 mph, quarter-mile, horsepower and torque from independent road tests.

Independent road tests for the Yaris of this era, listed by trim and engine — this page spans more than one engine, so no single horsepower figure is shown.

9.4 sec0–60 mph (tested)quickest 9.40 sec — 2020 XLE 5-door Hatchback
YearTrim / engine0–60¼ mileHPDrivetrain
2020XLE 5-door Hatchback 1.5L I-49.40 sec17.20 sec106 hpFWD

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

Torque lug nuts to Hatchback: 76 ft-lbs; Sedan: 80-108 ft-lbs.

Engine torques

Engine Flywheel Bolts83.0 ft-lbs
Oil Pump to Cylinder BLock Bolts/Studs17.0 ft-lbs

Chassis torques

Lug NutsHatchback: 76 ft-lbs; Sedan: 80-108 ft-lbs

Battery & A/C

RefrigerantR134a
Refrigerant Capacity0.73-0.86 lbs
Oil Type46
Oil Capacity2.03 oz
Oil GroupPAG
Standard BCI Group Number35
Standard BCI Cranking Performance355 cca

Service checks

Engine Oil Pressure4.2 psi @ Idle, 22-80 psi @ 3000 rpm psi
Intake Valve Lash0.008 in
Exhaust Valve Lash0.012 in

Multi-step torque procedures OEM · verified

Camshaft Bearing/Carrier Cap Bolts or Studs — tightening sequence 1 stages
140.0 inch lbs., Step 2: 84.0 inch lbs. Tighten bolts in an alternate pattern. Start at the center and work to the outside going side to side.40 in
Connecting Rod (Large End) Bearings — tightening sequence 1 stages
118.0 ft. lbs., Step 2:90°18 ft. lbs
Main Bearings — tightening sequence 1 stages
1Bolt A30 ft. lbs

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 7,500 mi; spark plugs every 75,000 mi.

Every 7,500 miBrake System (inspect) · Engine Oil (drain & refill) · Engine Oil Filter (replace) · Floor Mat (inspect) · Tire & Wheel Assembly (rotate) · Universal Vehicle Operation (inspect all fluid levels)
At 15,000 miCabin Air Filter (inspect)
Every 15,000 miAir Conditioning Condenser (inspect) · Brake Drum Assembly (inspect) · Brake Linings (inspect) · Brake Rotor (inspect) · Engine Coolant System (inspect fluid level) · Radiator (inspect)
Every 30,000 miBody Fasteners (torque) · Brake Line (inspect) · CV Joint Boot (inspect) · Cabin Air Filter (inspect) · Cabin Air Filter (replace) · Fuel Evaporative Emission Control System Lines (inspect)
Every 37,500 miAccessory Drive Belt (inspect) · Engine Air Filter Element (replace)
Every 45,000 miExhaust System (Complete) (inspect)
Every 60,000 miEmission Control System (inspect)
Every 75,000 miSpark Plugs (replace)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

The 2020 Toyota Yaris shows marked improvement over its predecessor, with 9 complaints and a single recall compared to 26 complaints, three recalls, and one NHTSA investigation in 2019. This follows a generation-wide pattern where complaint volumes spiked in 2007 (296 complaints) during the model's introduction, then gradually stabilized to single digits through 2018 before a brief resurgence in 2019. The 2020 model year represents a return to that lower complaint baseline, suggesting either successful resolution of 2019 issues or natural model-year refinement. With zero crash complaints, zero fire complaints, and the lowest TSB count (73) in the dataset's history, the 2020 Yaris appears to be the most problem-free model year in this generation. This makes it a comparatively low-risk purchase within this generation's timeline, provided the single recall has been addressed.

1
Open recalls
NHTSA campaigns
73
Service bulletins
Manufacturer communications
0
ODI investigations
Office of Defects Investigation
9
Owner complaints
0 involved a crash · 0 a fire
NHTSA crash-test rating federal NCAP · out of 5 stars
Overall★★★★★
Frontal★★★★★
Side★★★★★
Rollover★★★★
Owner complaints by model year NHTSA · this generation & adjacent

Owner complaints filed with NHTSA, by component

All 9 complaints on record, top 7 components.

Fuel System, Gasoline3
Vehicle Speed Control,Service Brakes,Forward Collision Avoidance1
Electrical System,Unknown Or Other,Engine1
Vehicle Speed Control,Unknown Or Other1
Engine1
Unknown Or Other,Engine1
Electrical System,Seat Belts1

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 1 of 1 campaigns on record for this vehicle.

21V617000Fuel System, Gasoline:Delivery:Fuel PumpReported 27/09/2021

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 Yaris, Yaris Hatchback, and Yaris Sedan vehicles. An impeller within the low-pressure fuel pump may crack and deform, potentially causing… Remedy: Dealers will replace the low-pressure fuel pump assembly, free of charge. Owner notification letters were mailed December 30, 2021. Owners may contact Toyota customer service at…

Technical service bulletins NHTSA · verified

Showing 5 of 73 bulletins on record with NHTSA.

BulletinDateComponentSummary
T-SB-0055-24 Rev22026-01-07Unknown Or OtherSome 2005 – 2026 Toyota vehicles that have undergone water intrusion may exhibit a…
T-SB-0035-24 Rev22024-12-06StructureAcid rain results from rainwater or other airborne moisture that become acidic due to…
T-SB-0038-24 Rev22024-12-06StructureTo prevent brake rotor rust from forming during transportation and storage, wheel film…
T-SB-0039-24 Rev22024-12-06StructureThe condition known as acid rain is caused by airborne chemicals or particles in the…
T-SB-0061-23 Rev22024-12-05StructureToyota vehicles are currently protected with RapgardTM protective film designed to…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420
Catalyst system efficiency below threshold — Bank 1
P0300
Random / multiple cylinder misfire detected
P0171
System too lean — Bank 1
P0455
Evaporative emission system leak detected — large leak
P0128
Coolant thermostat below regulating temperature
P0442
Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN
Decode a VIN to confirm the transmission and build data for a specific Yaris. OEM
Build data
Plant, GVWR class, engine and body data for any 17-character VIN.
Recalls
Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Reference guides

Cross-vehicle references for the kinds of data on this page.

Frequently asked

Does the 2020 Yaris have open recalls?

NHTSA lists 1 recall campaign(s) for this model year. Check your specific vehicle by VIN.

What gas mileage does the Yaris get?

EPA figures are 32 city / 40 highway / 35 combined mpg.