Lincoln›Navigator›2007›Overview/lincoln/navigator/2007/base/

2007 Lincoln Navigator

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2007 Navigator.

Body SUVTransmission Automatic 6-spd

The 2007 Lincoln Navigator is an SUV equipped with a six-speed automatic transmission and an engine requiring 7.0 quarts of 5W-20 API oil, returning an EPA fuel economy of 12 city, 17 highway, and 14 combined mpg. Its 45 documented owner complaints—primarily concerning hydraulic service brakes alongside two recalls—outline specific mechanical focal points for researchers. When viewed against the model's entire complaint history spanning 1997 to 2027, this year sits well below the 1998 peak of 209 complaints, signaling a moderately reliable standing rather than a historically troubled one.

Model year2025 2024 2023 2022 2021 2020 2019 2018 2007

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity7.0 qtOEM · verified

Engine oil type5W-20 APIOEM · verified

Lug nut torque150 ft-lbsOEM · verified

EPA fuel economy12/17/14 mpgEPA · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 65 ex. Climate Seats · 650 ex. Climate Seats CCA battery. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 65 ex. Climate Seats · 650 ex. Climate Seats CCAOEM · verified

Tire sizeP255-70R18OEM · verified

Wheel / rim8.5 inOEM · verified

Full specifications

Engine, drivetrain, dimensions and economy.

Engine & drivetrain NHTSA vPIC

Transmission

Automatic 6-spd

Dimensions & weight NHTSA vPIC

Overall length	208.3 in
Overall width	78.7 in
Overall height	78.3 in
Wheelbase	118.9 in
Curb weight	6069 lb
Track (front / rear)	66.9 / 67.3 in
Weight distribution (front / rear)	51/49

Ratings & economy EPA / vPIC

EPA city / highway / combined	12 / 17 / 14 mpg
Drivetrain	Rear-Wheel Drive
Recommended fuel	Regular Gasoline

Performance & power Independent road tests

0–60 mph, quarter-mile, horsepower and torque from independent road tests.

Independent road tests for the Navigator of this era, listed by trim and engine — this page spans more than one engine, so no single horsepower figure is shown.

8.3 sec0–60 mph (tested)quickest 8.30 sec — 2007 Ultimate

Year	Trim / engine	0–60	¼ mile	HP	Drivetrain
2007	Ultimate 5.4L V8	8.30 sec	16.30 sec	300 hp	4x4
2015	Reserve EcoBoost 3.5L Twin-Turbo V6	6.20 sec	14.90 sec	380 hp	4x4
2015	Reserve EcoBoost 3.5L twin-Turbo V6	6.20 sec	14.80 sec	380 hp	4x4
2015	Reserve EcoBoost 3.5L Twin-Turbo V6	6.50 sec	15.10 sec	380 hp	4x4
2016	L Reserve EcoBoost 3.5L Twin-Turbo V6	6.50 sec	14.90 sec	380 hp	4x4

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 7.0 qt of 5W-20 API engine oil, SYNTHETIC · 75W-140 · GL-5 in the differential. Torque lug nuts to 150 ft-lbs, the oil drain plug to 10.0 ft-lbs. The firing order is 1-3-7-2-6-5-4-8. Note the cylinder-head bolts finish on a torque angle (torque-to-yield) — they stretch permanently and should be replaced, not reused, during any head service.

Lubricants & capacities

Automatic Transmission Fluid	ATF
Automatic Transmission Fluid Capacity	9.5
Differential Gear Oil	SYNTHETIC · 75W-140 · GL-5
Differential Gear Oil Capacity	4.2 Pints, Rear
Differential Gear Oil	SYNTHETIC · 75W-140 · GL-5
Differential Gear Oil Capacity	4.2 Pints, Rear
Engine Oil	5W-20 · API
Engine Oil Capacity	7.0 qt

Engine torques

Exhaust Manifold to Cylinder Head Bolts	18 ft-lbs
Engine Oil Pan Drain Plug	10.0 ft-lbs

Chassis torques

Lug Nuts	150 ft-lbs
Transfer Case Fill Plug	11.0 ft-lbs
Transfer Case Drain Plug	11.0 ft-lbs
Front Wheel Hub	20 ft-lbs
Rear Wheel Hub	254 ft-lbs

Ignition

Cylinder Firing Order	1-3-7-2-6-5-4-8
Ignition Timing	10

Battery & A/C

Refrigerant	R134a
Refrigerant Capacity	Less auxiliary A/C, 1.38. With auxiliary A/C, 2.06. lbs
Oil Group	PAG
Oil Type	46
Oil Capacity	7.00 oz
Standard BCI Group Number	65 ex. Climate Seats
Standard BCI Cranking Performance	650 ex. Climate Seats cca
Optional BCI Group Number	65 w/ Climate Seats

Service checks

Pressure Test	13-18 psi
Radiator Cap Pressure Relief	13-18 psi
Thermostat Opening Temperature	188-195 °F
Key ON Engine OFF (KOEO)	35-45
RPM	28-45 @ Idle rpm
Engine Oil Pressure	40-125 psi
Engine Oil Pressure RPM	2500 rpm

Brakes

Torque Caliper to Bracket	26 ft-lbs / 41 ft-lbs
Torque to Knuckle	140 ft-lbs / 148 ft-lbs
Minimum Pad Thickness	Front: 0.118; Rear: 0.118 in
Minimum Pad Thickness	Front: 0.118; Rear: 0.079 in
Rotor Minimum Machining	1.086 in
Rotor Discard at or Under	1.259 in / 0.748 in
Rotor Max Parallel Variation	0.0005 in
Rotor Runout Limit	0.001 in

Multi-step torque procedures OEM · verified

Cylinder Head — tightening sequence 3 stages

Prep Do not reuse old bolts. Coat new bolts lightly with specified oil

1	30.0 ft. lbs.	30 ft. lbs
2	90 degrees	90 degrees
3	90 degrees	90 degrees

Intake Manifold to Engine Bolts — tightening sequence 1 stages

1.5 ft. lbs., Step 2: 7.4

1.5 ft. lbs

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 5,000 mi; spark plugs every 100,000 mi; coolant every 50,000 mi. The big-interval services (every 50,000 mi for coolant, and the transmission fluid) are the ones owners most often skip — on a lower-mileage example, assume the original fluids are still in it and check them first.

Every 5,000 mi	Engine Oil (drain & refill) · Engine Oil Filter (replace) · Tire & Wheel Assembly (rotate)
Every 15,000 mi	Brake System (inspect) · Cabin Air Filter (replace) · Driveshaft U-Joint (inspect) · Engine Coolant System Hoses (inspect) · Steering Linkage (lubricate) · Steering System (inspect)
Every 30,000 mi	Engine Air Filter Element (replace) · Exhaust System (Complete) (inspect) · Fuel Filter (replace) · Temperature Controlled Seat Air Filter (replace)
Every 50,000 mi	Engine Coolant System (drain, flush & refill)
Every 60,000 mi	Wheel Bearing (repack)
At 100,000 mi	Engine Coolant System (drain, flush & refill)
Every 100,000 mi	Accessory Drive Belt (inspect) · Spark Plugs (replace)
At 150,000 mi	Drive Axle Assembly (drain & refill) · Drive Belt (replace) · PCV Valve (inspect) · Transfer Case Assembly (drain & refill) · Transmission Fluid & Filter (replace)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

The 2007 Lincoln Navigator sits at a relatively low point in the complaint and recall arc of its generation. Complaints dropped to 45 from 60 in 2006 and from a peak of 127 in 2003, while TSBs fell to 27—the lowest in the early 2000s—indicating that many earlier issues had been addressed. Recalls remained modest at two, and there were no federal investigations, contrasting with the spike in recalls and TSBs seen in later model years (e.g., 2018 onward). The top complaint areas—service brakes, structure, fuel system, and electrical system—along with four fire complaints, suggest specific but not widespread problems. Compared to the volatile early 2000s and the high-complaint late 2010s, 2007 represents a stable midpoint. This makes it a reasonable buy if you prioritize lower reported issues, but a pre-purchase inspection focusing on the brake and fuel systems is advisable.

Open recalls

NHTSA campaigns

Service bulletins

Manufacturer communications

ODI investigations

Office of Defects Investigation

Owner complaints

2 involved a crash · 4 a fire

NHTSA crash-test rating federal NCAP · out of 5 stars

Rollover★★★★★

Owner complaints by model year NHTSA · this generation & adjacent

’97 ’98 ’99 ’00 ’01 ’02 ’03 ’04 ’05 ’06’07’08 ’09 ’10 ’11 ’12 ’13 ’14 ’15 ’16 ’17 ’18 ’19 ’20 ’21 ’22 ’23 ’24 ’25 ’26 ’27

Owner complaints filed with NHTSA, by component

All 45 complaints on record, top 8 components.

Service Brakes, Hydraulic6

Structure4

Fuel/Propulsion System4

Electrical System4

Unknown Or Other3

Fuel System, Gasoline3

Power Train2

Vehicle Speed Control2

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 2 of 2 campaigns on record for this vehicle.

08V058000Latches/Locks/Linkages:Doors:LatchReported 05/02/2008

FORD IS RECALLING 123,632 MY 2007-2008 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES. THE DOOR HANDLE HOUSING EMBOSSMENT RETAINING THE BOTTOM OF THE INTERIOR DOOR HANDLE SPRING ON ALL SIDE DOORS MAY FRACTURE DURING NORMAL… Remedy: DEALERS WILL REPLACE THE INTERIOR HANDLE SPRING ON ALL SIDE DOORS. THE RECALL BEGAN ON MARCH 5, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

08V057000Fuel System, Gasoline:Fuel Injection System:Fuel RailReported 05/02/2008

FORD IS RECALLING 57,199 MY 2006-2007 E-150, E-250, E-350, AND MY 2007 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES EQUIPPED WITH 5.4L ENGINES. THE FUEL RAIL CROSS-OVER HOSE MAY CONTAIN WEAK AREAS. AS A RESULT, THE HOSE… Remedy: DEALERS WILL REPLACE THE FUEL RAIL ASSEMBLY. THE RECALL BEGAN ON MARCH 3, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Technical service bulletins NHTSA · verified

Showing 5 of 27 bulletins on record with NHTSA.

Bulletin	Date	Component	Summary
TSB 24-2188	2024-07-24	Wheels	This article supersedes TSB 22-2219 to update the Parts List and Service Procedure to…
SSM 51909	2023-09-07	Power Train	When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV…
SSM 51536	2023-04-04	Structure	For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis…
TSB 22-2219	2022-06-21	Power Train	Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 (non-Raptor) vehicles equipped…
TSB 20-2307	2020-10-16	Electrical System	Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 vehicles equipped with TOD…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420

Catalyst system efficiency below threshold — Bank 1

P0300

Random / multiple cylinder misfire detected

P0171

System too lean — Bank 1

P0455

Evaporative emission system leak detected — large leak

P0128

Coolant thermostat below regulating temperature

P0442

Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN

Decode a VIN to confirm the transmission and build data for a specific Navigator. OEM

Build data

Plant, GVWR class, engine and body data for any 17-character VIN.

Recalls

Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Group 65 battery Vehicles taking 7.0 qt

Reference guides

Cross-vehicle references for the kinds of data on this page.

Vehicle recalls & TSBs OBD-II trouble codes Torque specifications Maintenance schedules Fluid capacities & specs

Frequently asked

How much oil does the 2007 Navigator take?

7.0 qt of 5W-20 API, per the factory manual.

Does the 2007 Navigator have open recalls?

NHTSA lists 2 recall campaign(s) for this model year. Check your specific vehicle by VIN.

What gas mileage does the Navigator get?

EPA figures are 12 city / 17 highway / 14 combined mpg.