ChevroletBlazer 2WD2002Overview/chevrolet/blazer-2wd/2002/base/

2002 Chevrolet Blazer 2WD

Factory specifications, fluid capacities, torque values, EPA fuel economy and the federal safety record for the 2002 Blazer 2WD.

Transmission Automatic 4-spd

The 2002 Chevrolet Blazer 2WD pairs a four-speed automatic transmission with EPA fuel-economy ratings of 15 mpg city, 20 mpg highway, and 17 mpg combined, and routine oil service calls for 4.5 quarts of 5W-30 API oil. In owner-reported data spanning 1990 through 2022, the 2002 model logged 259 complaints—far below the 1995 peak of 1,418 yet nowhere near the 2008 low of 5—with exterior lighting cited as the top problem area and two recalls on record. That places the 2002 Blazer 2WD in the middle of the model's long reliability arc: not the most troubled year, but one that still warrants attention to its lighting systems and recall work.

Model year200219941983

Quick specs

Fluid capacities, tune-up values and fuel economy at a glance.

Engine oil capacity4.5 qtOEM · verified
Engine oil type5W-30 APIOEM · verified
Lug nut torque100 ft-lbsOEM · verified
EPA fuel economy15/20/17 mpgEPA · verified

Fitment & sizes

Replacement part sizes and factory part numbers — battery, bulbs, filters and belts.

From the factory this vehicle uses a BCI 75 · 525 CCA battery, OE oil filter 19210286. Each part links to every other vehicle that shares it, so a part you already stock may fit more of your fleet than you'd expect.

Battery groupBCI 75 · 525 CCAOEM · verified
Tire sizeP245-70R16OEM · verified
Wheel / rim7-J inOEM · verified

OE service part numbers OEM · verified

Engine oil filter19210286 alt 12731175
Engine air filter19259086 alt 25170512
Fuel filter25168594
Spark plug12681665
Front wiper blades15757007 alt 15757008
Serpentine belt12576453 alt 19355374
Thermostat12632948 alt 12551507

Full specifications

Engine, drivetrain, dimensions and economy.

Engine & drivetrain NHTSA vPIC

TransmissionAutomatic 4-spd

Dimensions & weight NHTSA vPIC

Overall length176.8 in
Overall width67.7 in
Overall height64.6 in
Wheelbase100.4 in
Curb weight3847 lb
Track (front / rear)54.7 / 54.7 in
Weight distribution (front / rear)55/45

Ratings & economy EPA / vPIC

EPA city / highway / combined15 / 20 / 17 mpg
DrivetrainRear-Wheel Drive
Recommended fuelRegular Gasoline

Service quick specs OEM factory data

Capacities, torques and tune-up values from the factory service manual.

This engine holds 4.5 qt of 5W-30 API engine oil. Torque lug nuts to 100 ft-lbs, the oil drain plug to 18.0 ft-lbs. The firing order is 1-6-5-4-3-2.

Lubricants & capacities

Engine Oil5W-30 · API
Engine Oil Capacity4.5 qt

Engine torques

Crankshaft Pulley and/or Damper Bolts74 ft-lbs
Engine Oil Pan Drain Plug18.0 ft-lbs
Engine Valve Cover Bolts8.85 ft-lbs

Chassis torques

Leaf Spring to Axle (U-bolts)74.0 ft-lbs
Leaf Spring to Chassis Bracket89.0 ft-lbs
Leaf Spring to Rear Shackle89.0 ft-lbs
Leaf Spring Rear Shackle to Chassis Bracket89.0 ft-lbs
Lug Nuts100 ft-lbs
Transfer Case Fill Plug18.0-30.0 ft-lbs
Transfer Case Drain Plug18.0-30.0 ft-lbs
Front Wheel Hub103 ft-lbs

Ignition

Cylinder Firing Order1-6-5-4-3-2
Spark Plug ManufacturerAC Delco
Spark Plug Gap0.060 in
Spark Plug Torque11-14 ft-lbs

Battery & A/C

RefrigerantR134a
Refrigerant Capacity1.75-2.00 lbs
Oil GroupPAG
Oil Type46
Oil Capacity8.00 oz
Standard BCI Group Number75
Standard BCI Cranking Performance525 cca
Optional BCI Group Number75

Service checks

Pressure Test20 psi
Radiator Cap Pressure Relief15 psi
Thermostat Opening Temperature188-206 °F
Fuel Pump Pressure Minimum66.0 psi
Key ON Engine OFF (KOEO)60-66
RPM50-63 @ Idle rpm
Injector Primary Resistance11-14 @ 50-90 degreesF ohms
Engine Compression100

Brakes

Brake ApplicationWITH FOUR WHEEL DISC / WITH STANDARD
Torque to Knuckle77 ft-lbs / 52 ft-lbs / 38 ft-lbs
Minimum Pad ThicknessFront: 0.030; Rear: 0.030 specification
Brake ApplicationWITH FOUR WHEEL DISC / WITH STANDARD
Rotor Max Parallel Variation0.0003 in / 0.0005 in
Rotor Runout Limit0.003 in / 0.004 in
Rotor Nominal Thickness From1.14 in / 0.787 in / 1.03 in
Rotor Nominal Thickness To1.14 in / 0.787 in / 1.03 in

Factory maintenance schedule OEM · verified

Normal service, condensed from the factory interval matrix.

Under the factory schedule, replace the engine oil and filter every 7,500 mi; spark plugs every 100,000 mi; coolant at 150,000 mi. The big-interval services (at 150,000 mi for coolant, and the transmission fluid) are the ones owners most often skip — on a lower-mileage example, assume the original fluids are still in it and check them first.

At 7,500 miDrive Axle Assembly (drain & refill)
Every 7,500 miAxle Shaft Oil Seal (inspect) · CV Joint Boot (inspect) · Differential (inspect fluid level) · Engine Oil (drain & refill) · Engine Oil Filter (replace) · Tire & Wheel Assembly (rotate)
At 15,000 miEngine Air Filter Element (inspect)
Every 30,000 miEngine Air Filter Element (inspect) · Engine Air Filter Element (replace) · Fuel Filter (replace)
Every 50,000 miTransfer Case Assembly (drain & refill) · Transmission Fluid & Filter (replace)
Every 60,000 miAccessory Drive Belt (inspect)
Every 100,000 miPCV Valve (inspect) · Spark Plug Wires (inspect) · Spark Plugs (replace)
At 150,000 miEngine Coolant System (drain, flush & refill)

Reliability & federal safety record

Owner-reported issues, recalls, investigations and service bulletins on record with NHTSA — an unfiltered look at what owners actually experience.

Owner complaints about the 2002 Chevrolet Blazer 2WD lead in one area — the exterior lighting, 46 of 259 reports (18%), well ahead of the next concern. That matters, because the exterior lighting are also the target of recalls 08V-231 and 01V-364 on this vehicle — so the single most useful check before buying or servicing one is confirming they were actually performed. 16 of the reports describe a crash and 6 a fire — a small share of the total, but worth weighing against the exterior lighting pattern above. These are tallies of what owners actually reported to the federal government, not an editorial score — and higher-selling models naturally rack up more reports.

2
Open recalls
NHTSA campaigns
0
Service bulletins
Manufacturer communications
0
ODI investigations
Office of Defects Investigation
259
Owner complaints
16 involved a crash · 6 a fire

Owner complaints filed with NHTSA, by component

All 259 complaints on record, top 8 components.

Exterior Lighting46
Power Train27
Engine & Engine Cooling16
Electrical System15
Air Bags13
Visibility13
Fuel System, Gasoline12
Steering12

Source: NHTSA Office of Defects Investigation complaint database.

Recalls NHTSA · verified

Showing 2 of 2 campaigns on record for this vehicle.

08V231000Exterior Lighting:Brake Lights:SwitchReported 21/05/2008

GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT… Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT…

01V364000Exterior Lighting:Brake Lights:SwitchReported 03/12/2001

VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP… Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY…

Common OBD-II trouble codes

The most common OBD-II codes for this vehicle's emissions system. These are standardized SAE J2012 definitions, not vehicle-specific fault reports.

P0420
Catalyst system efficiency below threshold — Bank 1
P0300
Random / multiple cylinder misfire detected
P0171
System too lean — Bank 1
P0455
Evaporative emission system leak detected — large leak
P0128
Coolant thermostat below regulating temperature
P0442
Evaporative emission system leak detected — small leak

VIN tools

Decode factory build data for a specific vehicle by VIN.

VIN
Decode a VIN to confirm the transmission and build data for a specific Blazer 2WD. OEM
Build data
Plant, GVWR class, engine and body data for any 17-character VIN.
Recalls
Check open recall campaigns against a specific vehicle by VIN.

Vehicles with shared specs

Find every vehicle that shares this one's battery, bulbs, oil capacity, platform or parts.

Reference guides

Cross-vehicle references for the kinds of data on this page.

Frequently asked

How much oil does the 2002 Blazer 2WD take?

4.5 qt of 5W-30 API, per the factory manual.

Does the 2002 Blazer 2WD have open recalls?

NHTSA lists 2 recall campaign(s) for this model year. Check your specific vehicle by VIN.

What gas mileage does the Blazer 2WD get?

EPA figures are 15 city / 20 highway / 17 combined mpg.